What's Wrong With This Z06 ?!

[Mako Koiwai]

Preceded by a big cloud of smoke, while banging on the rev limiter in 2nd ... but car seems to be running fine. Slight 2nd puff of smoke and then nothing. Left back side of car is covered is white powder.

Gary said he's never seen this. I'm guessing a ceramic CAT element pulverized itself?

[Mako Koiwai]

Left rear is covered with white powder:

[Glenn Duensing]

John DeLorean says it's nothing, just left-over residue from following the white lines

[Steve Ekstrand]

Pillsbury Dough Boy RIP

[Bob Pl]

Raise the car & bang on the dr side cat w/ a dead blow mallet. If you hear tinkle, tinkle cat matrix is toast. You may not hear anything if all the matrix is gone. Also rev car while tapping cat (if you can manage to do this) & see if any pieces fly out the back.

How many miles on it? Year?

Clean it up (except the white powder) & remove all evidence of spirited driving. Drive to dealer. May be covered under emissions extended warranty.

You might go to where the white puff happened & CSI it for debris.

[Mako Koiwai]

Here's a plug of ceramic CAT cat that blew out of a 275 wheel horse power Mini. But what we saw blow out of the Vette was a BIG cloud of white "smoke," which turns out to probably be powder.

The Z06 in question use to have Nitros ... wonder if that contributed to the CAT's early demise?

[Will Kalman]

They should not run the engine until they check the cats. Broken up catalyst can actually work it's way UP into the engine if the vibrations are just right.

[Steve Ekstrand]

Nitrous can cause crazy exhaust temperature swings. I imagine the cat wouldn't like that much.

[Chuck Fowler]

The Z06 in question use to have Nitros ... wonder if that contributed to the CAT's early demise?

if that's the car i'm thinking of, and considering who installed the NOS system, the current owner might ask the installer to replace the CAT

[Nicole Wong]

The Z06 in question use to have Nitros ... wonder if that contributed to the CAT's early demise?

if that's the car i'm thinking of, and considering who installed the NOS system, the current owner might ask the installer to replace the CAT

Why are we dancing around who owns this car?? I only know 1 vette with that smiley face sticker on it

[Ron Flaherty]

They should not run the engine until they check the cats. Broken up catalyst can actually work it's way UP into the engine if the vibrations are just right.

This bothers me, please explain!!!!!

Mako nailed the prob on-site "looks like the cat exploded" checking the cel code showed we had lost the DS cat....just need to find out why, motor may have gone way lean riding the limiter???

thanks for all the input

(gotta pull my smiley sticker to hide from Nicole)

[Jason Isley BS RX8]

They should not run the engine until they check the cats. Broken up catalyst can actually work it's way UP into the engine if the vibrations are just right.

This bothers me, please explain!!!!!

Mako nailed the prob on-site "looks like the cat exploded" checking the cel code showed we had lost the DS cat....just need to find out why, motor may have gone way lean riding the limiter???

thanks for all the input

(gotta pull my smiley sticker to hide from Nicole)

It is a Corvette, they do this. :unimpressed: The T1 guys killed them so often they got the Club Racing rules changed to allow them to come off. I replaced them twice on my C4. Small cats very close to the header=fail. Replace them now and you should be good for a few years.

[Tom Berry]

If any help.. I have a couple of 99 Vette cats that have less than 25 k on them.

[Jason Isley BS RX8]

If any help.. I have a couple of 99 Vette cats that have less than 25 k on them.

I think the Z uses a different one... My dad got some take offs from a 00' non Z and they were different dia than his.

[Tom Berry]

So that would fall under the "No help" catagory

[Chad Stubblefield]

thats a good thing
you want the cat vaporized
your in stock class
Is it legal to not replace a vaporized cat?

[Mako Koiwai]

Should have removed that tattle tale Smilie!

[Ron Flaherty]

Thanks everyone for your input on my jinxed Z06.!!!!!!
dealer warranty work will not work, (NOS install) Looking for CATS...I can get high flow, not legal for $100.00, stock legal, $450.00???? ASP is looking very nice

[George Schilling]

Thanks everyone for your input on my jinxed Z06.!!!!!!
dealer warranty work will not work, (NOS install) Looking for CATS...I can get high flow, not legal for $100.00, stock legal, $450.00???? ASP is looking very nice

Or you could sell the car and buy an old Miata for $450.

[Chuck Fowler]

Thanks everyone for your input on my jinxed Z06.!!!!!!
dealer warranty work will not work, (NOS install) Looking for CATS...I can get high flow, not legal for $100.00, stock legal, $450.00???? ASP is looking very nice

Or you could sell the car and buy an old Miata for $450.

if were going to spend their $$, i vote for the MGB
viewtopic.php?f=8&t=2370

[George Schilling]

Thanks everyone for your input on my jinxed Z06.!!!!!!
dealer warranty work will not work, (NOS install) Looking for CATS...I can get high flow, not legal for $100.00, stock legal, $450.00???? ASP is looking very nice

Or you could sell the car and buy an old Miata for $450.

if were going to spend their $$, i vote for the MGB
viewtopic.php?f=8&t=2370

But they're used to cars that start when you turn the key.

[Steve Abbott]

Thanks everyone for your input on my jinxed Z06.!!!!!!
dealer warranty work will not work, (NOS install) Looking for CATS...I can get high flow, not legal for $100.00, stock legal, $450.00???? ASP is looking very nice

High flow cats probably will not pass the smog test. They don't clean the air as good as the stock ones.

Steve A.

[Bob Beamesderfer]

Thanks everyone for your input on my jinxed Z06.!!!!!!
dealer warranty work will not work, (NOS install) Looking for CATS...I can get high flow, not legal for $100.00, stock legal, $450.00???? ASP is looking very nice

Or you could sell the car and buy an old Miata for $450.

if were going to spend their $$, i vote for the MGB
viewtopic.php?f=8&t=2370

But they want a competitive car. Like mine.
viewtopic.php?f=8&t=978&start=0&st=0&sk=t&sd=a" onclick="window.open(this.href);return false;